TROUBLE DIAGNOSES — Consult (Cont'd)
EF & EC-247spec tableDATA MONITOR MODE
NOTE
Remarks: • Specification data are reference values. • Specification data are output/input values which are detected or supplied by the E.C.U. at the connector.
* Specification data may not be directly related to their components signals/values/operations. i.e. Adjust ignition timing with a timing light before monitoring IGN TIMING, because the monitor may show the specification data in spite of the ignition timing not being adjusted to the specification data. This IGN TIMING monitors the data calculated by the E.C.U. according to the signals input from the crank angle sensor and other ignition timing related sensors.
Data Monitor Mode
CAS, RPM (REF)
CONDITION• Tachometer: Connect • Run engine and compare tachometer indication with the CONSULT value.
SPECIFICATIONAlmost the same speed as the CONSULT value.
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Crank angle sensor
AIR FLOW MTR
CONDITION• Engine: After warming up, idle the engine • A/C switch "OFF" • Shift lever "N" — Idle
SPECIFICATION0.7 - 1.1V
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Air flow meter
AIR FLOW MTR
CONDITION• Engine: After warming up, idle the engine • A/C switch "OFF" • Shift lever "N" — 2,000 rpm
SPECIFICATION1.1 - 1.5V
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Air flow meter
ENG TEMP SEN
CONDITION• Engine: After warming up
SPECIFICATIONMore than 70°C (158°F)
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Engine temperature sensor
CAR SPEED SEN
CONDITION• Turn drive wheels and compare speedometer indication with the CONSULT value.
SPECIFICATIONAlmost the same speed as the CONSULT value.
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Vehicle speed sensor
BATTERY VOLT
CONDITION• Ignition switch: ON (Engine stopped)
SPECIFICATION11 - 14V
CHECK ITEM WHEN OUTSIDE SPEC.• Battery • E.C.U. power supply circuit
THROTTLE SEN
CONDITION• Ignition switch: ON (Engine stopped) — Throttle valve fully closed
SPECIFICATIONApprox. 0.5V
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Throttle sensor • Throttle sensor adjustment
THROTTLE SEN
CONDITION• Ignition switch: ON (Engine stopped) — Throttle valve fully opened
SPECIFICATIONApprox. 5.0V
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Throttle sensor • Throttle sensor adjustment
START SIGNAL
CONDITION• Ignition switch: ON → START
SPECIFICATIONOFF → ON
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Starter switch
IDLE POSITION
CONDITION• Ignition switch: ON (Engine stopped) — Throttle valve: Idle position
SPECIFICATIONON
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Throttle sensor • Throttle sensor adjustment
IDLE POSITION
CONDITION• Ignition switch: ON (Engine stopped) — Throttle valve: Slightly open
SPECIFICATIONOFF
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Throttle sensor • Throttle sensor adjustment
AIR COND SIG
CONDITION• Engine: After warming up, idle the engine — A/C switch "OFF"
SPECIFICATIONOFF
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Air conditioner switch
AIR COND SIG
CONDITION• Engine: After warming up, idle the engine — A/C switch "ON"
SPECIFICATIONON
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Air conditioner switch
NEUTRAL SW
CONDITION• Ignition switch: ON — Shift lever "P" or "N"
SPECIFICATIONON
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Neutral switch
NEUTRAL SW
CONDITION• Ignition switch: ON — Except above
SPECIFICATIONOFF
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Neutral switch
PW/ST SIGNAL
CONDITION• Engine: After warming up, idle the engine — Steering wheel in neutral (forward direction)
SPECIFICATIONOFF
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Power steering oil pressure switch
PW/ST SIGNAL
CONDITION• Engine: After warming up, idle the engine — The steering wheel is turned
SPECIFICATIONON
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Power steering oil pressure switch
FUEL PUMP RLY
CONDITION• Ignition switch is turned to ON (Operates for 5 seconds) • Engine running and cranking • When engine is stopped (stops in 1.0 seconds)
SPECIFICATIONON
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Fuel pump relay
FUEL PUMP RLY
CONDITIONExcept as shown above
SPECIFICATIONOFF
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Fuel pump relay
RADIATOR FAN
CONDITION• Engine: After warming up, idle the engine • A/C switch "OFF" — Engine temperature is below 90°C (194°F)
SPECIFICATIONOFF
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Radiator fan relay • Radiator fan
RADIATOR FAN
CONDITION• Engine: After warming up, idle the engine • A/C switch "OFF" — Engine temperature is above 91°C (196°F)
SPECIFICATIONON
CHECK ITEM WHEN OUTSIDE SPEC.• Harness and connector • Radiator fan relay • Radiator fan
