Periodic Maintenance (For Europe except U.K.) - Maintenance Under Severe Driving Conditions
MA-10spec tableEurope except U.K. severe-conditions schedule. Engine families SR series, GA series, CD series (diesel). Off-road section applies to 4x4 only.
Maintenance Under Severe Driving Conditions
The maintenance intervals shown on the preceding pages are for normal operating conditions. If the vehicle is mainly operated under severe driving conditions as shown below, more frequent maintenance must be performed on the following items as shown in the table.
SEVERE DRIVING CONDITIONS
Severe Driving Conditions legend
A
DescriptionDriving under dusty conditions
B
DescriptionDriving repeatedly short distances
C
DescriptionTowing a trailer or caravan
D
DescriptionExtensive idling
E
DescriptionDriving in extremely adverse weather conditions or in areas where ambient temperatures are either extremely low or extremely high
F
DescriptionDriving in high humidity areas or in mountainous areas
G
DescriptionDriving in areas using salt or other corrosive materials
H
DescriptionDriving on rough and/or muddy roads or in mud
I
DescriptionDriving with frequent use of braking or in mountainous areas
Engine oil service
A B C D
Maintenance itemEngine oil & oil filter — Gasoline engine
Maintenance operationReplace
Maintenance intervalEvery 6 months or 5,000 km (3,000 miles)
Ref page SR seriesMA-33
Ref page GA seriesMA-22, 23
Ref page CD series—
A B C D
Maintenance itemEngine oil & oil filter — Diesel engine
Maintenance operationReplace
Maintenance intervalEvery 3 months or 5,000 km (3,000 miles)
Ref page SR series—
Ref page GA series—
Ref page CD seriesMA-54, 55
Standard service
A
A . . E
F
G H
Maintenance itemSteering gear & linkage, axle & suspension parts, (propeller shaft (4WD)), drive shafts & exhaust system
Maintenance operationCheck
Maintenance intervalEvery 12 months or 20,000 km (12,000 miles)
Ref page SR seriesMA-65, FA-6, 9, RA-4
Ref page GA seriesMA-65, FA-6, 9, RA-4
Ref page CD seriesMA-65, FA-6, 9, RA-4
A . C . . G H I
. C . . . . H
Maintenance itemAutomatic & manual transaxle oil (transfer & differential gear oil (4WD))
Maintenance operationReplace
Maintenance intervalEvery 24 months or 40,000 km (24,000 miles)
Ref page SR seriesMA-59, 60, 61
Ref page GA seriesMA-59, 60, 61
Ref page CD seriesMA-59, 60, 61
NOTE
Maintenance operation: Check = Check. Correct or replace if necessary.
Maintenance for off-road driving (4x4 only)
Whenever you drive off-road through sand, mud or water, more frequent maintenance may be required of the following items: Brake pads and discs; Brake lining and drums; Brake lines and hoses; Differential, transaxle and transfer oil; Steering linkage; Propeller shafts and drive shafts; Air cleaner filter; Clutch housing (Check water entry. Refer to page MA-65.).
See also
MA-20Checking Cooling System (Cont'd) / Checking Fuel Lines / Changing Fuel FilterMA-21Changing Fuel Filter (Cont'd) / Cleaning and Changing Air Cleaner FilterMA-22Cleaning and Changing Air Cleaner Filter (Cont'd) / Changing Engine OilMA-23Changing Oil Filter / Checking and Changing Spark PlugsMA-25Checking P.C.V. System (Cont'd) / Checking Vacuum Hoses / Checking A.T.C. Air CleanerMA-31Checking Cooling System (Cont'd) / Checking Fuel Lines / Changing Fuel FilterMA-32Changing Fuel Filter (Cont'd) / Changing Air Cleaner FilterMA-33Changing Engine Oil / Changing Oil FilterMA-54Engine Maintenance — Fuel Line Check / Air Cleaner Filter / Water Draining, Fuel Filter / Fuel System Air Bleeding (CD)MA-55Engine Maintenance — Engine Oil Change / Engine Oil Filter Change (CD)MA-59Chassis and Body Maintenance — Checking/Changing M/T Oil, Checking A/T Fluid LevelMA-60Chassis and Body Maintenance — Checking/Changing A/T Fluid, Checking/Changing Transfer OilMA-61Chassis and Body Maintenance — Propeller Shaft, Differential Gear Oil, Brake FluidMA-62Chassis and Body Maintenance — Brake System, Brake Fluid, Brake Booster, Disc BrakeMA-63Chassis and Body Maintenance — Disc Brake (Caliper, Pad), Drum Brake (Wheel Cylinder, Drum)MA-65Chassis and Body Maintenance — Steering Gear and Linkage, Power Steering Fluid, Water Entry
FA-6 · FA-9 · RA-4